Bedford Rascal Workshop Manuals and Repair Manuals
Every Manual available online - found by our community and shared for FREE. Enjoy!
Bedford Rascal
The Bedford Rascal (later Vauxhall Rascal), also built as the Suzuki Super Carry is a microvan that was developed as a joint venture between General Motors (GM) and Suzuki. It was sold under GM's British-based Bedford marque as well as in Suzuki form. Other names were used in a few international markets, such as GME (General Motors Europe) for those continental European markets where Suzukis were generally not marketed and where the "Bedford" and "Vauxhall" brands were largely unknown.The van was produced at the IBC Vehicles plant in Luton, England, adjacent to the main Vauxhall factory (GM's British-based passenger car marque). Alongside the Bedford, the Suzuki-branded twin was manufactured for the European market (where Bedford is a less established brand).Sold from 1986 to 1994, the Rascal, like the Super Carry, was a small and economical van intended for many purposes. The vehicle's strengths were its diminutive size and maximum payload weight; 550 kg for the van and 575 kg for the pickup.[32] The principal visible difference between Bedford and Suzuki versions is the front trim: the Super Carry has two separate plastic headlamp surrounds and the Rascal has a single full width one with "Bedford" moulded in the middle.
Bedford Rascal FAQ's
How do I change the oil in my Bedford Rascal?
To change the oil in your Bedford Rascal, first locate the oil drain bolt underneath the engine. Place a drain pan underneath the bolt and remove it with a wrench. Let the oil drain completely before replacing the bolt and adding new oil.
How do I check the transmission fluid in my Bedford Rascal?
To check the transmission fluid in your Bedford Rascal, first make sure the engine is warmed up and running. Locate the transmission dipstick, which is usually located near the back of the engine bay. Pull it out, wipe it clean, and reinsert it. Pull it out again and check the fluid level.
How do I replace a blown fuse in my Bedford Rascal?
To replace a blown fuse in your Bedford Rascal, first locate the fuse box, which is usually located near the driver's side footwell. Use the fuse diagram to locate the fuse for the affected component and use a fuse puller or pliers to remove it. Replace it with a new fuse of the same amperage.
How do I replace a headlight bulb in my Bedford Rascal?
To replace a headlight bulb in your Bedford Rascal, first remove the headlight assembly by removing the screws or clips that hold it in place. Then, remove the bulb by twisting it counterclockwise and pulling it out. Replace it with a new bulb and reassemble the headlight assembly.
How do I replace the air filter in my Bedford Rascal?
The air filter in your Bedford Rascal is located in the engine bay. Open the hood and locate the air filter housing. Release the clips or screws that hold the housing in place and remove the old filter. Replace it with a new filter and secure the housing back in place.
How do I replace the battery in my Bedford Rascal?
To replace the battery in your Bedford Rascal, first locate the battery in the engine bay. Use a wrench to remove the negative cable from the battery, followed by the positive cable. Remove the battery from the vehicle and replace it with a new one. Reconnect the positive cable followed by the negative cable.
How do I replace the brake pads in my Bedford Rascal?
To replace the brake pads in your Bedford Rascal, first remove the wheel and locate the brake caliper. Use a wrench to remove the bolts that hold the caliper in place and remove it. Then, remove the old brake pads and replace them with new ones. Reinstall the caliper and wheel.
How do I replace the spark plugs in my Bedford Rascal?
To replace the spark plugs in your Bedford Rascal, first locate the spark plug wires. Disconnect them from the spark plugs by pulling them off. Use a spark plug socket and a ratchet to remove the old plugs and replace them with new ones. Reconnect the spark plug wires.
How do I troubleshoot a starting problem in my Bedford Rascal?
If your Bedford Rascal is having trouble starting, first check the battery and connections to make sure they are clean and tight. If the battery is fine, check the starter motor and solenoid to make sure they are functioning properly. It may also be a fuel or ignition problem, which may require further diagnosis.
How often should I change the oil in my Bedford Rascal?
It is recommended to change the oil in your Bedford Rascal every 3,000 miles or every 3 months, whichever comes first. This will help keep your engine running smoothly and improve fuel efficiency.
How often should I replace the battery in my Bedford Rascal?
It is recommended to replace the battery in your Bedford Rascal every 3 to 5 years, depending on usage and conditions. This will help ensure reliable starting and prevent electrical issues.
How often should I replace the brake pads in my Bedford Rascal?
It is recommended to replace the brake pads in your Bedford Rascal every 30,000 miles or as soon as you notice signs of wear, such as squeaking or reduced braking power. This will help keep you and your vehicle safe on the road.
How often should I replace the spark plugs in my Bedford Rascal?
It is recommended to replace the spark plugs in your Bedford Rascal every 30,000 miles or every 2 years, whichever comes first. This will help keep your engine running smoothly and improve fuel efficiency.
How often should I replace the timing belt in my Bedford Rascal?
It is recommended to replace the timing belt in your Bedford Rascal every 60,000 miles or every 5 years, whichever comes first. This will help prevent engine damage and costly repairs.
How often should I replace the transmission fluid in my Bedford Rascal?
It is recommended to replace the transmission fluid in your Bedford Rascal every 30,000 miles or every 2 years, whichever comes first. This will help keep your transmission running smoothly and prevent costly repairs.
What is a Bedford Rascal?
The Bedford Rascal is a light commercial vehicle produced by Bedford in the United Kingdom from 1986 to 1993. It is a small van that was primarily used for transportation of goods and people. It was also sold under the name Suzuki Supercarry in some markets.
There are currently no manuals available for Bedford Rascal at this time.
Related Models
